2006 Toyota Tacoma Underbody Shields Problems
- 48
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- rust frame · 13 records
- frame rust · 6 records
- frame rusted · 6 records
- severe rust · 5 records
- same problem · 5 records
- failure mileage · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 16 |
| 30–60k mi | 13 |
| 100–150k mi | 9 |
| 1–30k mi | 3 |
| 150–400k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Underbody Shields
Tl* the contact owns a 2006 toyota tacoma. The contact stated that the undercarriage was rusted out and the vehicle was dangerous to drive. The vehicle was taken to team toyota langhorne (746 e lincoln hwy, langhorne, pa 19047, [redacted]), but was not diagnosed. The dealer sprayed the undercarriage with an anti-corrosion ointment, but the repair failed. The contact stated that there were presently holes in the…
ODI 11209265
Body · Underbody Shields
Tl* the contact owns a 2006 toyota tacoma. While using the pressure washer to wash the undercarriage of the vehicle, the contact noticed excessive amounts of rust emitting from the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified. The contact was informed that there was a limited manufacturer's extended warranty on the vehicle, which had expired. The vehicle was included in nhtsa…
ODI 10907699
Structure · Suspension · Underbody Shields
2006 toyota tacoma. Consumer writes in regards to dealerships refusal to repair vehicle frame corrosion/holes safety recall. *smd the consumer was informed there was no recall, but a limited service campaign. The consumer also stated the leaf spring broke and was held with into place with a wire. Updated 03/01/17.*jb
ODI 10883239
Underbody Shields
Tl* the contact owns a 2006 toyota tacoma. The contact stated that the frame underneath the vehicle was corroded. The dealer stated that the frame needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 73,000.
ODI 10660793
Underbody Shields
2006 toyota tacoma trd sport access cab. Found hole on frame rail from rust, about 3/4" hole behind the right front wheel, below the condenser drain. *tr
ODI 10641578
Underbody Shields
The body of my tacoma is perfect --no rust. The frame however exhibits stage iv cancer rust. Toyota knows about it as they sued '[xxx]" the frame manufacturer and received millions in compensation and in 2009 went with a different manufacturer. In august 2014 they came out with limited campaign for select vin #'s 2005-2008 tacomas sold in the northeast to either treat or replace rusted frames. Mine however was not…
ODI 10641288
Suspension · Underbody Shields
I bought my toyota tacoma new in febuary of 2006.a couple of months ago i noticed that the whole frame on my truck is rusted pretty bad.the springs are rusted as is the clips that hold them togoether.when i rubbed my finger over the rust on the frame chunks of rust about 1 eighth of a inch thick just fell off a you could still see rust on the frame under where the chunk came off.i only have 56000 miles on this truck…
ODI 10643735
Suspension · Underbody Shields
We left our truck at a toyota dealership for repair of rattle in front end, state inspection and oil change. The vehicle was returned to us without repair as there is an abnormal amount of rust on the frame and holes through the frame. We were informed that the vehicle will not pass inspection. I called toyota customer service and was informed that our vehicle is not included in the previous recall, but may be…
ODI 10638258
Suspension · Underbody Shields
As i was driving home my truck started making a noise from the back end. When i got home i looked at the underside of the truck and both spring shackles were rusted away and holes in the frame above them. The frame is completely rusted and i am unable to drive it because it could cause an accident. I called toyota about it and they said we apologize for the problem but we aren't going to fix it. *tr
ODI 10620905
Steering · Suspension · Underbody Shields
Returning home with my grandson from visiting a state university i head a knocking sound in the front of the vehicle. I thought a rubber bushing had failed because previous models of toyotas (tercels) made the same sound when the torsion bar bushings needed to be replaced. Upon returning home i found the sway bar had come out of the left bracket which secures it to the frame and was striking the front left spring of…
ODI 10618572
Underbody Shields
Significant rust in the frame of the vehicle. Baseball size hole in the frame adjacent to the driver side catalytic converter. Major rust throughout the rest of the frame. You can see swelling in some areas where there are two layers of steel that are sandwiched together. Brake and fuel lines have severe corrosion. Factory installed towing hitch is completely un-usable due to severe rust. Toyota corporate told me i…
ODI 10611009
Body · Underbody Shields
My truck has been officially been declared unsafe to drive. I am experiencing extreme and unusual rust and corrosion on the frame of my 2006 toyota tacoma. This is not the kind of rust you would expect to see due to normal wear and tear. The first indication from my dealer that there was a problem was when i took the truck in on 07/10/14 for an oil change. I was told that the frame was so severely compromised by…
ODI 10637032
Underbody Shields
Vehicle failed pa inspection due to extensively rusted frame. The entire frame has been compromised. There are visible holes in the frame including spare tire support, gas tank supports, etc. The dealer and i both contacted toyota but they refuse to stand behind their product because the said they are not required to since no notice has come from nhtsb. According to the dealer, this same problem is known on earlier…
ODI 10607697
Engine · Underbody Shields
The vehicle frame is very corroded in numerous spots, especially in weld areas and behind the front wheels. Some fasteners also appear to be abnormally corroded. The engine accessory pulleys are also in very poor condition. The corrosion is odd in that it is not consistent. I mean that some components and fasteners show minor corrosion while others are excessive. The vehicle frame is also very corroded in isolated…
ODI 10605065
Underbody Shields
Frame rust deemed so bad by toyota tech that he refused to put the truck on a rack for inspection and service. *tr
ODI 10714144
Suspension · Underbody Shields
My 2006 toyota tacoma frame is terribly rusted even though i have had it cleaned and undercoated for beginners. But my main issue is the fact that my leaf springs already need replaced. They have been making creaking noises for several months because they are junk already. But then, the left side leaf spring completely cracked and that's not even effected by the rust. It's very frustrating to pay so much just to try…
ODI 10596868
Underbody Shields
My truck has severe rust in the front frame that appears to be rusting the body from the inside out! I purchased this vehicle new (toyota tacoma 2006) because i believed that toyota was a reputable company who stand by their claims of built to last. I also purchased a full maintenance program to be sure i was taking care of the vehicle properly and faithfully met every service. The dealer never pointed out a rust…
ODI 10594442
Suspension · Underbody Shields
I discovered that the frame on my toyota truck is excessively rusted. It is actually quite unbelievable when you compare the frame to everything else on the underside of the truck. Every other component on the underside is in pristine condition but there is hardly an area of the frame that is not rusted. There are some areas that have the classic "potato chip" scaling that has eaten through about 1/2 the original…
ODI 10568938
Underbody Shields
My 2006 toyota tacoma has 42,200 miles on it and the frame rotting by the day, due to rust. My truck cannot be driven. The bed creaks and shakes and is very unstable. The brackets holding the leaf springs are nearly disintegrated, deeming my vehicle stranded. Toyota will not do anything about it. When i purchased my vehicle from toyota in 2007, i paid for undercoating to protect from rust. Upon research, many 2006…
ODI 10564873
Structure · Suspension · Underbody Shields
On 2/15/2014 i changed the tires on my truck and noticed that the frame is experiencing severe rust nearly everywhere. I took the truck to the local dealership for routine maintenance based on the mileage. At that time i explained to the service department representative at the dealership my concern regarding the amount of rust to the frame and might this become a safety problem leading to a failure. The dealership…
ODI 10565919
Underbody Shields
I went to local toyota service and dealer for oil change and tire rotation.once the technician raised truck he inspected frame and found rust and cracks and 2 wholes, 1 on left side frame on inside and 1 on right side inside frame adjacent to front passenger door with a 6in crack running from whole . Service manager then called me to bay as soon as tech told him and showed me the rust and crack and wholes he then…
ODI 10562291
Underbody Shields
Took my toyota tacoma in to have snow tires put on the vehicle, the tech. Said the frame had rust holes in it and was unsafe to drive. Rust was flaking off all over the frame, this vehicle is only 7 yrs. Old they are sending a inspector to see if toyota will pay for a new frame. I have a ford 450 2002 and it's frame is in much better shape. *tr
ODI 10555915
Underbody Shields
At annual inspection mechanic noted rust holes in the frame and corrosion in connections of plates to frame. This is of course a safety hazard that prevents the vehicle from passing inspection. Dealer inspected and confirmed the corrosion. We purchased the truck new. We live on a dirt road with no salt use, keep the truck garaged in winter, and do not drive it regularly in winter. It is otherwise a sound and…
ODI 10551807
Underbody Shields
The frame on my 2006 toyota tacoma has a rust hole by the trans cross member. The frame is also rusted very badly. I drive 150 miles a day round trip to work and also my family in this vehicle. *tr
ODI 10550747
Suspension · Underbody Shields
Tl* the contact owns a 2006 toyota tacoma. The contact received a notification of nhtsa campaign number: 14v604000 (suspension). The contact stated that the part needed to remedy the vehicle was unavailable. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Updated 3/24/15*cn the consumer stated the leaf spring on the passenger failed. When it failed, it shot out underneath…
ODI 10672208