2005 Toyota Tacoma Body Problems
- 115
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 115 stored complaint records:
- 2 indicate a crash
- 0 indicate injury
- 0 indicate fire
What owners report
- failure mileage · 26 records
- frame rust · 14 records
- notified failure · 11 records
- failure failure · 10 records
- rust frame · 10 records
- approximate failure · 10 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 30 |
| 150–400k mi | 27 |
| 60–100k mi | 20 |
| 1–30k mi | 10 |
| 30–60k mi | 8 |
Complaint records
Owner-submitted complaint content, presented as stored.
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the front frame was corroded. The contact also mentioned that there was a hole in the metal frame where it began to separate. The vehicle was taken to a dealer, who stated that the front portion of the frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 98,000. ..updated 12-30-13 *bf the…
ODI 10554641
Body
On the top part of my hood on my 2005 toyota tacoma pre-runner. The paint is chipping/ flaking off to where the metal is being shown. The paint everywhere else on my truck is fine, except on the trim around the wheel-well is fading. The other problem is with the rear console latch which closes and opens the console broke after eight months of driving my truck. The latch did feel like it was sticky until i closed the…
ODI 10641892
Body
Vehicle will not pass inspection due to a hole in the frame. *tr
ODI 10552913
Body
There was no incident, but there is extensive rust on the frame of my truck. Pieces of rust regularly fall off while i'm parked in the driveway. I feel the amount of rust is excessive for the age of the car and is probably a danger. *tr
ODI 10552590
Body · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that upon inspection, it was found that the frame was perforated due to rust. The vehicle was taken to the dealer where the failure was confirmed. The vehicle was not repaired. The manufacturer was contacted about the failure. The failure mileage was 184,000. Updated 12/20/13*cn
ODI 10552493
Body
Took truck for inspection failed for multiple holes rusted thru frame am told i am not involved in any recall for frame replacement. *tr
ODI 10641047
Body
The frame is rusting and the door handles have rust stains bleeding all over the door. *js
ODI 10598008
Body
The frame is rotting through on the drivers side inside frame rail. The pressed c channel frame is also rotting and separating. I take very good care of my truck. People are constantly telling me. How good it looks for the year. It is ridiculous and toyota motor company is not doing anything. The dealer has contacted corporate and they do not intend to do anything about the 2005 and up tacoma frame rusting/rot…
ODI 10535268
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that while the vehicle was being inspected, it was found that the frame was perforated due to rust. The vehicle was not repaired. The manufacturer was contacted about the failure. The failure mileage was approximately 138,000.
ODI 10533844
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the vehicle was involved in a slight crash. The contact was not injured and a police report was not filed. The vehicle was deemed as destroyed because the frame was completely rusted and the contact was advised that although the vehicle could be repaired, it would not pass a state inspection. The contact spoke with the manufacturer but no assistance…
Crash reported
ODI 10532877
Body · Suspension
As i was leaving work i slowly drove over a speed bump. The rear end of my truck began to bounce like a boat in choppy water. I got out and looked to see if i had a low tire. All four tires were fine so i kept looking. Upon closer inspection to the left rear wheel well, i noticed that the shock rod had broken off at the theaded end and shot straight through the bed of my truck. I immediately took the truck to glenn…
ODI 10522095
Body
Bought a 2005 toyota tacoma, after having a look under the truck i noticed some rust on the frame, as i looked closer i found that the rust was so bad it was causing the frame to twist, i have contacted toyota and in the first 2 emails they said they will do nothing so i asked to speak to someone higher up to resolve this issue there is no recall yet and i do not know why. Other people i know with same issue same…
ODI 10607895
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the frame of the vehicle was rusted. The vehicle was taken to a dealer where the mechanic spray painted the frame, but the failure recurred. The contact stated that the remedy did not repair the vehicle. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.
ODI 10735691
Body · Suspension
FRAME FALLING APART! *TR
ODI 10691884
Body
I have a hole on the inside of box frame next to the cat. Converter on driver side. This was discovered back in january of 2013, and was immediately reported to the toyota rep over the dealership. I've inquired about the situation 3 times since then and have just gotten the answer that its under investigation. This hole which i can almost stick my fist through looks to be located in the crumble zone, and is in a…
ODI 10532341
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the spare tire fell and detached from the vehicle. The spare tire was located under the vehicle and the contact stated that the entire cross member on the rear of the vehicle became rusted. The contact stated that half of the rear cross member also fractured and detached from the vehicle. The contact also stated that the cross member that was located…
ODI 10488801
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that he noticed a hole in the frame of the vehicle due to rust. The vehicle was taken to a dealer, who confirmed there was a hole in the frame of the vehicle. The manufacturer was notified and the contact was informed that the vehicle was not included in any recalls. The vehicle was not repaired. The failure and current mileage was 98,000.
ODI 10494468
Body
Last year during vehicle inspection i was told my frame had rust. I checked with toyota and they had a recall for model years up to 2004 for frame rust issues. This year while my truck was on the lift for mechanical work, the mechanic informed me that the rust on my frame was getting serious and there were some possible weak area's. Again i contacted toyota and they said they have had no issues nor seen any rust on…
ODI 10472866
Body · Steering
While driving the steering became very difficult to turn to the left or the right direction. This is caused by a faulty design of the steering shaft universal joints. The frame is also rusting very badly and i am concerned about the integrity of the vehicle. *tr
ODI 10545638
Body · Steering
2005 toyota tacoma first issue is the steering, on several occasions while turning the steering has "locked up" , the steering gets extremity hard to turn in the middle of driving. After my own research i discovered the universal joint on the steering shaft will lock up or get extremely hard to turn if not greased. The joint is open to the elements and has no protective boot over it. There is no maintenance…
ODI 10574588
Body
I own a 2005 toyota tacoma, 4x4, 4-cylinder, 5-speed manual, purchased new. It has 92,000 miles on it and i have filed two complaints, going back three years, with my dealer and with toyota headquarters regarding excessive rust on the frame of my vehicle. Both have told me it is acceptable for the frame to be rusting. I disagree. A vehicle that should easily last over 200,000 miles should be built on quality frames.…
ODI 10437980
Body · Steering
Excessive rust began appearing on the frame of the vehicle at 50,000 miles. Reviewed rust with toyota dealership (4 times over the last 3 years) and this vehicle is not included in any recalls for a rusty frames. My concrete driveway is now stained with the rust coming off of the vehicle. Frame and bumper is now rusty and getting weaker as the rust continues. Vehicle now has 90,000 miles and frame is covered in…
ODI 10508073
Body · Engine And Engine Cooling
Truck began making loud noises in engine compartment. Truck was diagnosed as having bad motor mounts. At time of repair, motor mount assemblies were noted by mechanic to have broken off the frame due to bad/weakened welds. Motor is rubbing on fan/radiator shroud. Owner has done independent research, including complaints filed on this site, and has noted that this has been an on-going issue with 2005 tacomas. *tr
ODI 10424436
Body · Power Train
My 2005 toyota tacoma quad cab sr5 has an issue with the transmission. At a complete stop with my foot firmly on the brake my truck lunges forward in a very dangerous abrupt manner as though someone rear ended me. This happens often at stop lights a few seconds after i come to a complete stop. A second issue is that my paint is cracking and peeling on my roof and my clear coat is noticeably bad on the edges of my…
ODI 10439055
Body
Rust has developed on frame of my 2005 toyota tacoma. Despite prior rust issues with this model toyota has no program in effect to look at the truck. *tr
ODI 10454898