2005 Toyota Tacoma Body Problems
- 115
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 115 stored complaint records:
- 2 indicate a crash
- 0 indicate injury
- 0 indicate fire
What owners report
- failure mileage · 26 records
- frame rust · 14 records
- notified failure · 11 records
- failure failure · 10 records
- rust frame · 10 records
- approximate failure · 10 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 30 |
| 150–400k mi | 27 |
| 60–100k mi | 20 |
| 1–30k mi | 10 |
| 30–60k mi | 8 |
Complaint records
Owner-submitted complaint content, presented as stored.
Body
Tl- the contact owns a 2005 toyota tacoma. The contact stated that the vehicle had developed severe corrosion and a hole near the drivers side tire. The contact who was a certified mechanic stated that the frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 194,000. Pam
ODI 10653511
Body
Vehicle's frame is rusting and flaking apart. The vehicle was taken to a toyota dealership per their limited service campaign to apply a corrosion-resistant compound. One year later that compound is starting to fall off as the rust beneath it lets loose. Since there is physically less frame material than when the truck was built i feel that this vehicle would suffer considerable damage in a collision as the the…
ODI 10781865
Body · Engine And Engine Cooling
The catalytic converter shield on my 2005 tacoma fell off while driving and almost caused an accident. After picking up the large metal parts and inspecting under the vehicle, i noticed that near to where the catalytic converter sits, that there was extensive corrosion on the truck's frame and even a large hole. I am extremely worried about the safety of the vehicle and am afraid that the frame may crumple while…
ODI 10662411
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated while receiving a state inspection, the mechanic noticed that there was corrosion on the frame. Prior to the inspection the dealer had also replaced the emergency brake line because corrosion was present as well the manufacturer was notified of the failure and the approximate failure mileage was 125,000.
ODI 10628762
Body
The frame of my 2005 tacoma has developed a hole. I have only owned the vehicle since march of 2013, and have complained about it to the dealer since a month after buying it. The metal is flaking off all over the frame and toyota has issued a limited service campaign, but they are claiming they can not do anything until they move the campaign to my area. I do not feel safe driving this vehicle. But i have to, and…
ODI 10609866
Body
2005 tacoma resided in pa from purchase in 2004 until july 2011 & is now exhibiting frame perforation in the area of both exhaust resonators and splitting in the c-channel rails near the rear wheels. *tr
ODI 10651064
Body
Corrosion on frame rails affecting structural integrity of frame. Rust holes are present. *tr
ODI 10655366
Body
I all ready have a complaint in odi- 10915902 i have pictures i would like to send.did my complaint in oct 2016 still waiting for paperwork.i have more pictures not sure how to send them all.
ODI 10955328
Body
I have a 2005 toyota tacoma. This is my second toyota truck and i do really love my truck. My last pickup was a 1999 ext pickup with a lot of rust on it when i qualified for a buyback deal. Last week i brought my 2005 into the kenny ross toyota dealer in coraoplis, pa to have them inspect my vehicle. The inspection revealed a large structural hole in the frame of the vehicle. It is on the driver's side where the…
ODI 10587097
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that upon inspection, it was found that the frame was perforated due to rust. The vehicle was taken to the dealer where the failure was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage and current mileage was 189,000.
ODI 10587288
Body · Frame And Members
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the vehicle was taken to the dealer for an unrelated repair. The technician stated that the subframe of the vehicle was corroded and rusted. The manufacturer was notified of the failure. The failure mileage was 81,000.
ODI 10592474
Body · Power Train · Suspension
I have noticed excessive rust on the frame of my 2005 toyota tacoma and also rust hole through the frame/leaf spring mount on the right side. I did contact and send pictures to toyota customer experience center file# stating that the vehicle is out of warranty and they wont repair this unsafe condition that so many tacoma's are having. When one of these tacoma's gets into an accident with the frames compromised by…
ODI 10575560
Body · Suspension
I took my truck to get it inspected and they said there are holes in the frame a large as my hand. It will not pass inspection and cannot be driven. I have been driving my 2 little sons around in this vehicle which has been unsafe for a long time. The holes are big enough to have started years ago as a small hole which make the truck undrivable. I have a nice looking truck that cannot be driven. The 1st generation…
ODI 10572500
Body · Engine
Tl* the contact owns a 2005 toyota tacoma. The contact stated that while driving in reverse, he noticed the frame under the motor mount was deteriorated. The vehicle was taken to a certified mechanic, who diagnosed that the frame was rusted, deteriorated, and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the problem. The approximate failure mileage was 170,000. Updated…
ODI 10565785
Body · Service Brakes, Hydraulic · Vehicle Speed Control
I was pulling into a curb parking space when suddenly the engine on my truck accelerated. My foot was already on the brake so i pushed all the way to the floor but i was slowly moving forward anyway. My brakes were smoking from trying to stop my truck. I hit the back of a parked car and pushed it approximately two parking spaces before i thought to turn the engine off. *tr
Crash reported
ODI 10564124
Body
The frame is rusted and the vehicle will not pass inspection. *tr
ODI 10562502
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that upon inspection, it was found that the frame was perforated due to rust. The vehicle was taken to the dealer where the failure was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was not available. The vin was unavailable. *tr
ODI 10560936
Body · Suspension
The frame on my 2005 toyota tacoma pre runner is completely rusted out due to a flaw in the manufacturing process. The recall was 3 months past the date of the end of the recall. Now my vehicle has large cracks in the frame and is no longer safe. This issue still exists in the 2005 model and must be addressed for public safety. There was a recall that covered this problem up until the end of 2004. Mine was purchased…
ODI 10560442
Body · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that there was excessive rust on the frame. The contact called the manufacturer, who stated there was nothing they could do to assist. The failure mileage was 63,000. Updated 02/19/14*lj the consumer stated as of feb 10, 2014, he was still waiting on the district rep to inspect the vehicle. Updated 02/24/14
ODI 10560099
Body
Tl* the contact owns a 2005 toyota tacoma. The contact stated that the frame was rusted. Also, the contact mentioned that the motor mounts and the brackets were corroded. The manufacturer was made aware of the problem. The approximate failure mileage was 192,000.
ODI 10608852
Body · Temporary/Emergency Spare Tire
Summer 2012 the cross member holding the spare tire fell off while i was driving. Now (january 2014) a large (three inch) perforation has appeared in the front frame. The truck frame is rotting out fast. *tr
ODI 10559972
Body
Upon inspecting the underside of my 2005 tacoma, i discovered holes in both sides of the inner frame behind the front wheels that had rusted right through the frame. The rust continues to spread and the holes are getting larger. *tr
ODI 10559339
Body · Power Train · Suspension
Started hearing rubbing/grinding type noise coming from front end. Inspected and found lf cv axle leaking grease, so thought the noise was coming from there. Replaced lf cv axle, and the noise did not go away. Inspected further and found drivers side frame where the motor mount bracket is welded to cracked, causing the motor to flex and the fan to rub on the fan shroud. Contacted toyota, who instructed me to get it…
ODI 10559528
Body · Suspension
During a repair visit to toyota service center i was informed that my frame was rusting in several places. I was told that at the present time the vehicle was safe to drive but that the rust would continue and lead to an unsafe condition. Toyota is aware of rusting problems with previous model years. I see that the 2004 and earlier model years were recalled for rusting frames. Dealerships was also aware of an…
ODI 10559642
Body
The tailgate of the vehicle lacks the required amount of structural integrity to serve its intended purpose. Since the tailgate is designed to be opened to a flat position for loading or unloading item(s) placed in the bed of the truck it will certainly require a certain amount of strength for this purpose. I noticed that my tail gate was no longer straight across when in the close position but had a concave…
ODI 10650422