2002 Toyota Tacoma Structure Problems
- 14
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- spare tire · 9 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 4 |
| 100–150k mi | 2 |
| 30–60k mi | 2 |
| 150–400k mi | 1 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Structure
Tl* the contact owns a 2002 toyota tacoma. The contact stated that while having the annual state inspection performed, the inspector notified him that the entire sub frame, rear bumper and front passenger side wheel well were excessively corroded. Neither the dealer nor the manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 167,152.
ODI 10622561
Structure
FRAME RUSTED AND CRACKED. *JS
ODI 10617311
Fuel System, Gasoline · Structure · Temporary/Emergency Spare Tire
My fuel tank is rusted completely through to the point of leaking gas. I know toyota has recalled the frame (replaced) and the spare tire holder (not yet replaced) due to rust. Seems like the whole underside is rusting out. *tr
ODI 10609269
Structure · Temporary/Emergency Spare Tire
Three months ago i received my notice about excessive corrosion of the spare tire carrier lift plate. I called the local toyota dealer to schedule the repair, the collision manager had no knowledge about it. I called again to schedule a fix but was told that some one will call me but ,no one did. Toyota of york ,pa17402. *tr
ODI 10594972
Structure · Temporary/Emergency Spare Tire
Sometime in 2012, my spare tire and rim were lost on the highway due to a failed spare tire carrier. The lift plate on the spare tire carrier, failed due to corrosion and released the spare tire (and rim) on the highway. No crash of incident occurred because no one was following the vehicle at the time. *tr
ODI 10561883
Structure · Unknown Or Other
I called toyota in 2012 to ask about frame. Was told i didn't qualify. Have had to replace everything attached to frame in a 2 year period. Last fall the gas tank fell off. Frame so rusted it wouldn't hold it. Called toyota again, as recommended by mechanic, was told i didn't qualify. Went to dealer for recall repair on spare tire holder, they couldn't fix it. Too rusted. Told me it s not safe to drive. Told me to…
ODI 10598296
Structure
Excessive amount of rust on frame of 2002 toyota tacoma pick-up. Frame shows extensive corrosion from inside working it's way out. I am very concerned that the life of this vehicle will be drastically reduced due to this issue. I understand that toyota is investigating this problem for years 95 through 2000. What about years newer than 2000 that are experiencing the same problem???? *tr
ODI 10227439
Structure · Tires
This is in response to the new toyota recall on the sienna mini-vans spare tire. I own a 2002 toyota tacoma, in which the frame was recently replaced due to rust perforation in certain states. I am the original owner and back in 8/2007 i had a flat tire and had to change it. The spare tire resides under the vehicle and is secured by a cable. When i went to access the spare, i noticed the whole cable and the…
ODI 10326078
Structure
Motor mount bracket broke on 2002 toyota tacoma 4x4 extra cab. Purchased vehicle used from royal toyota in bloomington, indiana on jan. 25, 2006, along with an extended warranty (36,000/36 month). Have driven it less than 3,000 miles - mostly highway. Discovered oil leak under the front. Fortunately, took it to a performance toyota in fairfield, ohio before the motor fell out. The bracket is not covered by the…
ODI 10152413
Structure
Rear bumper decay/structure breakdown on 2002 toyota tacoma. Unsafe in case of from the rear collision. Noticed start of rust/loss of structure in 2/2006. *tr
ODI 10286619
Structure
Purchased this vehicle as certified pre-owned vehicle. Massive leaks rendered back of drivers side crew cab flooded. Reversed drain plug previously installed up side down, then siliconed oem roof rack and leak slowed. Toyota is replacing rear door seal. Was not notified oem roof rack negated warranty. Cpv shouldn't leak. *nm
ODI 10154561
Cruise Control · Structure
Truck dash has rattled since shortly after we bought the truck. Never has been fixed correctly. Also, the cruise control doesn't keep you at consistent speed at all on mountains/hills. If you want to go 55, it will put you up over 60 very quickly and then gradually drop you down to around 55. *ak
ODI 10036867
Structure
Water is entering the vehicle around the support handle on the driver side of the vehicle. Vehicle was purchased one year ago. Problem became evident this past fall and when brought to the dealership this february they refused to repair under the corrosion warranty. Vehicle is over the standard warranty mileage.
ODI 10005837
Automatic Transmission · Structure · Suspension
For the last year i have brought truck back to sf toyota dealership for transmission problems , suspension problems rattling dash board, squeaking sounds from seat and front bushings. All these problems still have not been fixed. After 15 visits to dealership, sf toyota left scratches on body and lost mud flap. Body now tilted after service. *nlm
ODI 10031207