2005 Toyota Tacoma Underbody Shields Problems
- 71
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 71 stored complaint records:
- 1 indicate a crash
- 0 indicate injury
- 0 indicate fire
What owners report
- frame rust · 12 records
- rust frame · 8 records
- holes frame · 7 records
- rusted through · 7 records
- failure mileage · 6 records
- frame rusted · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 21 |
| 60–100k mi | 14 |
| 150–400k mi | 13 |
| 30–60k mi | 7 |
| 1–30k mi | 4 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that after refueling, one of the fuel tank straps fractured as a result of corrosion. The vehicle was taken to an independent mechanic. The manufacturer was made aware of the failure. The vehicle was not repaired. The vin was not available. The failure and current mileage was 85,000. Updated 06/17/14*lj the consumer stated one of the two straps that…
ODI 10586827
Underbody Shields
Original owner of a 2005 toyota tacoma, bought new in november 2004. 61000 miles. Vehicle mostly garaged when not in use. Frame and frame sub components are completely covered with rust. Several holes in frame, including one in the boxed section the size of a coca cola can. Several areas of the frame are delaminating, i.e. The layers of the metal are separating. Dealer refused to inspect the frame. Have contacted…
ODI 10593853
Underbody Shields
Safety inspection revealed extreame corrosion of the frame and weakening around the motor mount area of the frame, where the mounts are welded to the frame rails. Potential for loss of steering control if motor mount collapses through the frame rail and motor rests on steering shaft. I have done research about this problem and have discovered that there was an issue with the frames for model years 2005 and 2006…
ODI 10582996
Underbody Shields
I had this vehicle inspected by toyota and they stated surface rust on frame. This vehicle only has 47000 miles and the rust is not surface rust, in my opinion, for the mileage. The vehicle will continue to deteriorate if toyota doesn't do something about repairing or replacing the frame. Toyota has recalled 1995.5 through 2004 and have repaired or replaced frames. Toyota needs to continue their recall to include…
ODI 10572641
Fuel System, Gasoline · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that while driving approximately 5 mph and making a left turn, an abnormal noise was heard from under the body of the vehicle. The contact later discovered that the metal straps used to secure the fuel tank to the vehicle had rusted and fractured, causing the right front section of the fuel tank to hang from the vehicle. The contact also indicated that…
ODI 10565302
Underbody Shields
Vehicle at repair shop to be inspected and failed due to rust perforation of frame. Brought it to dealer and they took pictures and sent to toyota and still waiting. They stated up to 2004 year models were recalled for same problem but not the 2005 year models which makes no sense as 2005 is a newer model. The dealer stated that they are doing recalls in the boston area for this problem and it should come to ny…
ODI 10630250
Underbody Shields
I went to get my 2005 tacoma inspected today and it failed because there is a hole in the frame by the passenger side front wheel. I've been the only owner of this vehicle and was completely surprised that the frame has started to rust to the point where there are holes in it. This truck is primarily driven on the highway and wear and tear is pretty minimal. Inspecting the frame afterwards, the entire frame is…
ODI 10561479
Body · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that there was excessive rust on the frame. The contact called the manufacturer, who stated there was nothing they could do to assist. The failure mileage was 63,000. Updated 02/19/14*lj the consumer stated as of feb 10, 2014, he was still waiting on the district rep to inspect the vehicle. Updated 02/24/14
ODI 10560099
Underbody Shields
I took my toyota tacoma, 2005 in for a new headlight. The toyota dealer said that the inspection would run at month's end and would i like to take care of the inspection while i waited rather than making a second appointment. I said "yes", please do the inspection. The technician said the truck failed inspection due to a rusted frame. He called me back to view the rusted out frame, which i did to my shock and horror…
ODI 10560823
Underbody Shields
Massive amount of frame rust, worried about safety. Reviewed by toyota dealership service manager and toyota rep that happened to be at dealership. Was told that rust was not normal and pictures were taken, told that it was documented but not to expect further action. *tr
ODI 10559359
Underbody Shields
I have complained to toyota now for the past few years about excessive rust on the frame of my 2005 tacoma. I had even reported it on here before due to the amount of rust. My truck was at the toyota dealership and the service manager wanted to show me 2 holes in my frame as a result of rust. One hole was about the size of a golf ball and the other about the size of a marble. I have done some more research and near…
ODI 10552724
Body · Underbody Shields
Tl* the contact owns a 2005 toyota tacoma. The contact stated that upon inspection, it was found that the frame was perforated due to rust. The vehicle was taken to the dealer where the failure was confirmed. The vehicle was not repaired. The manufacturer was contacted about the failure. The failure mileage was 184,000. Updated 12/20/13*cn
ODI 10552493
Underbody Shields
Last month i looked underneath my truck and discovered significant frame rust. The most significant areas are between steel frame components that are riveted together. Rust has formed between these plates and is pushing them apart. There is up to 3/8" deformation between plates. The plates were originally in contact with each other. The plates are still in contact with each other at rivet points. The conditions of…
ODI 10554321
Underbody Shields
2005 tacoma failed inspection due to a hole in the frame from rust. Vehicle inspected by the dealer from which it was purchased. Had purchased vehicle just less than one year earlier, second owner. No accidents and well cared for. Ironically enough, we bought this tacoma to replace the 1998 tacoma we lost due to a frame rust problem in the toyota buyback program. Dealer did fix at no cost under used car warranty.…
ODI 10557712
Underbody Shields
Last fall, i was advised by a private garage that my 2005 tacoma had excessive frame rust. I brought it to my local toyota dealer for an inspection. They told me that the vehicle was not safe to drive and i should not drive it until the frame was repaired. I opened a case with toyota and have heard nothing. I wrote letters to the gm at the local dealership in lakewood, nj and the regional manager in nj, both of…
ODI 10575932
Underbody Shields
While getting my vehicle worked on a tech stated that there was a significant amount of rust on my frame. The toyota rep came to look at it and said it wasn't too bad but that i might want to sell the car in a year or two rather than deal with the rust. An 8 year old vehicle should not have a frame that rusted. *tr
ODI 10550162
Suspension · Underbody Shields
I am the original owner of a 2005 toyota tacoma pick up listed above. Back in the fall of 2013 i was advised by my local mechanic that my truck had frame rot near the front passenger side of the vehicle. I brought the truck to lia toyota in colonie, ny and they documented the problem. Several months past and i did not hear anything back from them. I called the natl customer service at [redacted], who advised that…
ODI 10573325
Underbody Shields
Was advised of severe rust problem on frame of vehicle by independent garage. Brought vehicle to local toyota dealer for inspection after opening a case with toyota (1308190057). Dealer service manager wrote on invoice "advised customer that hole in frame frt left side call #800 number for toyota no programs or warranty at this time. Advise customer to fix frame before driving cannot tell if there are any other…
ODI 10573790
Underbody Shields
After having my truck inspected, i was informed by my mechanic that the frame of my truck was rusting and in the future it will not pass inspection. To me this is ridiculous since i only have 36000 miles on my vehicle.toyota recalled the tacoma trucks between 2000 and 2004. Evidently some 2005 tacoma's should also be included in this recall. I have read online of other numerous people having the same problem. We…
ODI 10536519
Suspension · Underbody Shields
Took vehicle in for inspection, notified that the frame has excessive corrosion (rust) on the entire frame with signs of metal separation. A crack was also noted on the passenger side where the front and back parts of the c-frame are welded together. When the surface rust was ground away, the crack was 5" long and the bottom of the c-frame had two large perforations. With this condition, the vehicle will not pass…
ODI 10536594
Underbody Shields
Went to get vehicle inspection,dealer said frame has rotted to a unsafe degree and will not inspect. I cant use my $30,000 truck for work because of a known toyota frame rusting issue. *tr
ODI 10532107
Underbody Shields
Back in july of 2012 i purchased this truck from moritz chevrolet used cars in ft. Worth, texas. I was unaware of the frame rusting at the time. Rust on a frame is not usually an issue to even have to consider while buying a vehicle that new in texas. I moved to western pennsylvania in june and on my trip up i noticed the truck was vibrating/shimming. I took my truck in for service to barrel toyota in cranberry, pa…
ODI 10550287
Engine And Engine Cooling · Underbody Shields
On may 27, 2013 my wife [xxx] and i were towing my bass boat and i blew out the rear passenger tire and was able to safely get it off of the road to change the tire. In the process of changing the tire in my truck, the frame bent under the pressure of the jack and the truck, came off of the jack, luckily i had the tire partially on that the lug bolts caught the truck. This rusting and unsafe frame issue dates back…
ODI 10559798
Suspension · Underbody Shields
The toyota dealership where i purchased my new 2005 tacoma 7 yrs ago, informed me my truck will not pass state inspection due to holes rusted through the frame. The largest of the holes was located under the driver's side on the inside of the main box frame component. There are similar holes along other box style frame parts. These rust holes originated from the inside of the box frame and not from where any rust…
ODI 10513492
Underbody Shields
2005 tacoma with severe rust perforations to frame. Notifed vehicle unsafe to drive. Dealer will not warranty or assist. 8 yr old vehicle undrivable. I took my 2005 tacoma in to sevrco auto windward in kaneohe, hi on 25 april 2013 to have the vehicle inspected for severe rust perforations on the frame. When i dropped the vehicle off the attendant notified me that toyota had seen a number of these frame issues and…
ODI 10512430